Sand and debris getting into this can keep it from operating and cause all of the electrical circuitry beyond it to not be energized. Some Gasoline powered golf carts have a small micro switch at the foot pedal. We need to test for spark, fuel, and air. If the solenoid DOES engage and the engine turns over but doesn’t start, then this opens a whole slew of other testing procedures. There are extensive instructions for testing your solenoid on this page. If you have determined that the key switch and cabling between it and the solenoid are working properly, and you still don’t get the click, then let’s examine the solenoid. I have seen a stuck fuel tank float baffle a mechanic for three hours while looking for a reason for a “full” tank not delivering the fuel.Ĭheck the battery to make sure it’s fully charged and the terminals are free of any corrosion. How Do You Troubleshoot a Gasoline Golf Cart?Ĭheck the fuel level, regardless of what the gauge says. Here is a link to a few OEM Golf Cart Key Switches on Amazon. If the key switch fails any of these tests, it’s worn out and should be replaced. If this is a gasoline cart, set the switch to “ON” and take a reading between the terminals. There should be a reading or continuity between any combination. Check continuity between R, ACC, and B terminals. Now set the switch in the “REVERSE” position. There should be a reading or continuity (light on). Check continuity between F and B terminals. If this is an electric cart, set the switch in the “FORWARD” position. There should be no reading on the ohmmeter or no light on the continuity tester. Set the switch in the “OFF” position and check for continuity between all terminals and the case of the switch. This test is done with a battery-powered continuity tester or an ohmmeter set to X1. If this doesn’t fix the problem, let’s test the key switch. If the connections use a spade lug, pull the connection loose, wipe off the terminal, and plug it back in again. Check this over for corrosion on either end and make sure you’ve got a tight connection. This runs from your ignition switch to the starter solenoid. How To Start A Golf Cart Without A Key? Click Here!įind the ignition wire on your golf cart. Any space in between would cause an interruption in the electrical flow to the key switch. They do wear out from time to time.īefore troubleshooting the key switch make sure that your forward-reverse switch is fully in the forward, reverse, or neutral position. The Key Or Ignition SwitchĪssuming that you’ve already checked the battery to see if it’s charged, we next need to check the key switch itself. We do this because if there is a problem further down the circuitry, a replacement might burn out immediately and you wouldn’t know the difference. Test the fuse for continuity to see if it is really blown or not. Read the inside panel to locate the fuse or fuses and what rating they have. These are easy to check and eliminate from the troubleshooting procedure. Alternatively, it can be found in a compartment close to the battery. Typically, the fuse box of a Club Car golf cart is conveniently situated beneath the dashboard. Close to the battery (at least in the Yamahas), there is a service panel that contains electrical components…including fuses. Yes, sometimes the simplest items can cause the biggest problems. Troubleshooting Gas Golf Cart Problems And Starting Systems Fuses If there is no click when the pedal is pushed, then there is no solenoid activity. On Electric carts, the battery pack should be checked for a full charge. On gasoline carts, check the battery that turns the engine over to make sure it is charged. If nothing happens, it’s most likely an electrical issue. I learned that there are symptoms to watch for and what to do to fix the problem.įirst, you turn the key, press the pedal, and listen for a click. The first time my gas golf cart wouldn’t turn over, I was lost trying to figure out what to do next. Try these steps to troubleshoot and pinpoint the exact failure point. Any one of these areas can cause your golf cart to fail to start. Your gas golf cart won’t start if there is a problem with the fuel, airflow, or electrical system.
0 Comments
Leave a Reply. |
AuthorWrite something about yourself. No need to be fancy, just an overview. ArchivesCategories |